HDC SEREIS BATTERY 2VoltFast Charge Lead Carbon
BatteryHDC series lead-carbon batteries use functional
activated carbon and graphene as carbon materials, which are added
to the negative plate of the battery to make lead carbon batteries
have the advantages of both lead-acid batteries and super
capacitors. It not only improves the ability of rapid charge and
discharge, but also greatly prolongs the battery life. It is more
suitable for the application of PSOC.Some country/City/town/village
of the world, the on-grid power supply is unreliable with frequent
power outages. In these area, businesses depend on battery
solutions for backup power. However, due to the high frequency of
power outages in some regions, batteries are cycled very frequently
and are required to fast recharge - you never know when the next
outage will be. This is why CSBattery invented the fast charge long
life deep cycle lead-carbon batteries. HDC SERIES Fast Charge
DEEP CYCLE Lead Carbon BATTERYVoltage: 2VCapacity:
2V600Ah~2V3000AhDesigned floating service life: 15~20years
@25°C/77°FWhy the market need Lead Carbon batteryFailure modes of
flat plate VRLA lead acid batteries in case of intensive cyclingThe
most common failure modes are:- Softening or shedding of the active
material. During discharge the lead oxide (PbO2) of the positive
plate is transformed into lead sulfate (PbSO4), and back to lead
oxide during charging. Frequent cycling will reduce cohesion of the
positive plate material due to the higher volume of lead sulfate
compared to lead oxide.- Corrosion of the grid of the positive
plate. This corrosion reaction accelerates at the end of the charge
process due to the, necessary, presence of sulfuric acid.-
Sulfation of the active material of the negative plate. During
discharge the lead (Pb) of the negative plate is also transformed
into lead sulfate (PbSO4). When left in a low state-of-charge, the
lead sulfate crystals on the negative plate grow and harden and
form and impenetrable layer that cannot be reconverted into active
material. The result is decreasing capacity, until the battery
becomes useless.It takes time to recharge a lead acid
batteryIdeally, a lead acid battery should be charged a rate not
exceeding 0,2C, and the bulk charge phase should be followed by
eight hours of absorption charge. Increasing charge current and
charge voltage will shorten recharge time at the expense of reduced
service life due to temperature increase and faster corrosion of
the positive plate due to the higher charge voltage.Lead carbon:
better partial state-of-charge performance, more cycles long life,
and higher efficiency deep cycleReplacing the active material of
the negative plate by a lead carbon composite potentially reduces
sulfation and improves charge acceptance of the negative
plate.Features for Fast Charge Deep Cycle Lead Carbon
batteryCombine the characteristics of lead acid battery and super
capacitorLong life cycle service design, excellent PSoC and cyclic
performanceHigh power, rapid charging and dischargingUnique grid
and lead pasting designExtreme temperature toleranceAble to operate
at -30°C -60°CDeep Discharge recovery capabilityAdvantages for Fast
Charge Deep Cycle Lead Carbon batteryLess sulfation in case of
partial state-of-charge operation.Lower charge voltage and
therefore higher efficiency and less corrosion of the positive
plate.And the overall result is improved cycle life.Tests have
shown that our lead carbon batteries do withstand at least eight
hundred 100% DoD cycles.The tests consist of a daily discharge to
10,8V with I = 0,2C, followed by approximately two hours rest in
discharged condition, and then a recharge with I = 0,2C.≥ 1200
cycles @ 90% DoD (discharge to 10,8V with I = 0,2C, followed by
approximately two hours rest in discharged condition, and then a
recharge with I = 0,2C)≥ 2500 cycles @ 60% DoD (discharge during
three hours with I = 0,2C, immediately followed by recharge at I =
0,2C)≥ 3700 cycles @ 40% DoD (discharge during two hours with I =
0,2C, immediately followed by recharge at I = 0,2CApplications for
Fast Charge Deep Cycle Lead Carbon batteryØ Solar power generation
grid, Ø Off Grid energy storage systems, Ø Wind Power Systems,Ø
Hybrid energy storage systems, Ø Home energy storage systems, Ø
Telecom StationØ Renewable energy storage, Ø Smart power grids and
micro-grids systemØ Electric Powered Vehicles, Ø Golf Cars and
Buggies, Ø Tour bus, Ø Sweeper, Ø Floor cleaning machines,Ø Wheel
Chairs, Ø Power Tools, Ø Electric Powered Toys, Ø Control System, Ø
Medical Equipments,Ø Forklift, Ø Marine, Ø RV, Ø Boat, Ø Pumps, and
so on.HDC Delivery timeNormal, 30-35 days for production
with injection molding Lead-Carbon-plate by ourselfAs a
factory we Can Support Urgent project with 25-30days.OEM brand is
free chargeCSBattery Sealed Lead Carbon 2V Battery
HDC2-600-----------------------------------------------------------------------CSBattery
Sealed Lead Carbon 2V Battery HDC2-600 sepcificationHDC2-600N
Related products about Csbattery 2V600ah Bateria Reasonable Price Lead Carbon Battery for UPS-Inverter/Solar-Power-System/Home/Ada
- Waste Tyre Plastic Recycling Machinery Machine Tire Crusher Production Line Rubber Crumb Grinding Machine Equipment Tire Shredder
- Stretch Plastic Blowing Pet Bottle Making Blow Molding Machine Bottles Stretch Automatic Pet Bottle Blowing Machine
- Waste Plastic Pet Bottle, Water Bottle Flake, PP/HDPE/LDPE PE Film Jumbo Woven Bags Plastic Crusher Machine, Plastic Crushing Washing Recycling Machine
- Type 2 Wall-Mounted Electric Car Charging Station 7kw /11 Kwelectric Vehicle Charging Station Home Wallbox AC EV Charger Single Phase or 3three Phase
- G-View G12W Wholesale Auto Car LED Headlight Bulb High Power H13 H11 9005 H7 H4 Car LED Headlights LED Car Lights
- New Design Porcelain Round Plates Dinner Set for Wedding and Banquet
- China 2023 New Design Super Soft 100% Polyester Microfiber Knitted Oversized Decoration Hoodie Blanket
- Handmade Art Creative Materials Thickened White Paper Cup DIY Disposable Handmade Colored Paper Cup